- ISSN 1008-505X
- CN 11-3996/S
| Citation: |
ZHANG Hai-bin, MENG Hai-bo, SHEN Yu-jun, ZHAO Li-xin, ZHOU Hai-bin, DING Jing-tao. Effect of biochar addition on physicochemical properties and microbial population of biogas residue compost[J]. Journal of Plant Nutrition and Fertilizers, 2019, 25(2): 245-253. DOI: 10.11674/zwyf.17428
|
Biogas is an important and effective way in deal with the waste from intensive animal farming in China, however, the recycling use of biogas residue has become a bottleneck of restricting the development of biogas projects. This paper attempted to use the biogas residue to make safe compost.
The tested biogas residue was from a chicken farm, the biochar was made of fruit wood through pyrolysis at 550℃ for 2 h. The biogas residue was the main raw material, the pig manure and maize straw of 1 cm long were used to adjust the C/N to 25∶1, the moisture contents was controlled at 65%−70% during the composting. Biochar was added in rate of 0, 2%, 5% and 10% of the fermentation materials (dry-base ratio), and recorded as CK, F1, F2, and F3, respectively. The composting lasted 30 days at room temperature. The physical and chemical properties and the quality of composts were determined during the aerobic composting process.
During the composting process, the highest temperature in all the treatments reached above 55.0℃, and the high temperature lasted for 6 days in F1 and F2, which met the harmless requirements. The variation of pH and EC was the same, all showed the trend of increasing first and then decreasing, and finally tending to be flat. The pH values in all the four treatments were in range from 8.55 to 8.80, and the pH of F2 treatment was always higher than those of the other three groups (>8.7) with the maximum pH of 9.03 during the heating period. The electrical conductivity of all treatments was below 1 mS/cm. Compared with CK, the organic matter contents in F1, F2 and F3 were respectively reduced by 13.0%, 9.3% and 7.4%, nevertheless, they were all higher than 45%; the total nutrient contents were increased by 6.5%, 4.3% and 2.2%; the seed germination indices were all higher than 85%. The addition of biochar could increase the number of microbes, but the effects on bacteria, fungi and actinomycetes were different. With the increase of biochar addition proportion, the number of bacteria were reduced, the number of actinomycetes showed a concave trend and the greatest inhibitory effect was in F2, and the number of fungi was increased. The humus contents in composts of all treatments decreased first and then increased, showing the "V" shape, reaching the lowest value on the 11th day. The humic acid content in F1 treatment was higher than those in the other three groups, the highest value was 24.08%, the lowest was 17.92%. Compared with CK, the humus contents of the final product were increased by 8.12%, 7.23% and 7.43% in F1, F2 and F3 treatments, respectively.
The addition of biochar could prolong the high temperature duration, change the physical and chemical properties of biogas residue compost, promote the maturity and improve the total nutrient contents. Among the three addition proportions tested, the addition of 2% biochar (dry basis ratio) performs the best for the composting process.
| [1] |
李景明, 薛梅. 中国沼气产业发展的回顾与展望[J]. 可再生能源, 2010, 28(3): 1-5.
Li J M, Xue M. Review and prospect on biogas development in China[J]. Renewable Energy Resources, 2010, 28(3): 1-5.
|
| [2] |
牛俊玲, 高军侠, 李彦明, 等.堆肥过程中的微生物研究进展[J]. 中国生态农业学报, 2007, 15(6): 185-189.
Niu J L, Gao J X, Li Y M, et al. Evaluation of the role of microorganisms in composting[J]. Chinese Journal of Eco-Agriculture, 2007, 15(6): 185-189.
|
| [3] |
宋彩红, 夏训峰, 席北斗, 等. 响应曲面法优化沼渣混合物料堆肥配比研究[J]. 中国环境科学, 2012, 32(8): 1474-1479.
Song C H, Xia X F, Xi B D, et al. Optimization of biogas residue mixed with livestock manure co-composting using response surface methodology[J]. China Environmental Science, 2012, 32(8): 1474-1479.
|
| [4] |
牛明杰, 郑国砥, 朱彦莉, 等. 城市污泥与调理剂混合堆肥过程中有机质组分的变化[J]. 植物营养与肥料学报, 2016, 22(4): 1016-10232.
Niu M J, Zheng G D, Zhu Y L, et al. Dynamic of organic matter fractions during sewage sludge and bulking agent composting[J]. Journal of Plant Nutrition and Fertilizer, 2016, 22(4): 1016-10232.
|
| [5] |
张强, 孙向阳, 任忠秀, 等. 调节C/N及添加菌剂与木酢液对园林绿化废弃物堆肥效果的影响[J]. 植物营养与肥料学报, 2012, 18(4): 990-998.
Zhang Q, Sun X Y, Ren Z X, et al. Effects of regulating of C/N ratio and adding different concentrations of microbe fungus and wood vinegar on composting of landscaping waste[J]. Journal of Plant Nutrition and Fertilizer, 2012, 18(4): 990-998.
|
| [6] |
王小琳, 陈世昌, 袁国锋, 等. 促腐剂在鸡粪堆肥发酵中的应用研究进展[J]. 植物营养与肥料学报, 2009, 15(5): 1210-1214.
Wang X L, Cheng S C, Yuan G F, et al. Effects of transformation promoter on fermentation of chicken manure compost[J]. Journal of Plant Nutrition and Fertilizer, 2009, 15(5): 1210-1214.
|
| [7] |
Gerard C, Zofia K, Stavros K, et al. Relations between environmental black carbon sorption and geochemicals or bent characteristics[J]. Environ Science and Technology, 2004, 38(13): 3632-3640.
|
| [8] |
袁帅, 赵立欣, 孟海波, 等. 生物炭主要类型、理化性质及其研究展望[J]. 植物营养与肥料学报, 2016, 22(5): 1402-1417.
Yuan S, Zhao L X, Meng H B, et al. The main types of biochar and their properties and expectative researches[J]. Journal of Plant Nutrition and Fertilizer, 2016, 22(5): 1402-1417.
|
| [9] |
Busscher W J, Novak J M, Evans D E, et al. Influences of pecanbiochar on physical properties of a Norfolkloamy sand[J]. Soil Science, 2010, 175(1): 10-14.
|
| [10] |
Cheng C H, Lehmann J, Thies J E, et al. Oxidation of black carbon by biotic and abiotic processes[J]. Organic Geochemistry, 2006, 37: 1477-1488.
|
| [11] |
Steiner C, Das K C, Melear N, et al. Reducing nitrogen loss during poultry litter composting using biochar[J]. Journal of Environmental Quality, 2010, 39(4): 1236-1242.
|
| [12] |
Chen Y X, Huang X D, Han Z Y, et al. Effects of bamboo charcoal and bamboo vinegar on nitrogen conservation and heavy metals immobility during pig manure composting[J]. Chemosphere, 2010, 78(9): 1177-1181.
|
| [13] |
Dias B O, Silva C A, Higashikawa F S, et al. Use of biochar as bulking agent for the composting of poultry manure: Effect on organic matter degradation and humification[J]. Bioresource Technology, 2010, 101(4): 1239-1246.
|
| [14] |
Li H, Ying X C, Wei X W. Impacts upon soil quality and plant growth of bamboo charcoal addition to composted sludge[J]. Environmental Technology, 2012, 33(1): 6-68.
|
| [15] |
魏自民, 王世平, 魏丹, 等. 生活垃圾堆肥过程中有机态氮形态的动态变化[J]. 植物营养与肥料学报, 2005, 11(2): 194-198.
WEI Z M, WANG S P, WEI D, et al. Dynamic changes of organic nitrogen forms during the municipal solid wastes composting[J]. Journal of Plant Nutrition and Fertilizer, 2005, 11(2): 194-198.
|
| [16] |
候月卿, 沈玉君, 孟海波, 等. 生物炭和腐殖酸类对猪粪堆肥重金属的钝化效果[J]. 农业工程学报, 2014, 30(11): 205-215.
Hou Y Q, Zhao L X, Meng H B, et al. Passivating effect of biochar and humic acid materials on heavy metals during composting of pig manure[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2014, 30(11): 205-215.
|
| [17] |
沈玉君, 李国学, 任丽梅, 等. 不同通风速率对堆肥腐熟度和含氮气体排放的影响[J]. 农业环境科学学报, 2010, 29(9): 1814-1819.
Shen Y J, Li G X, Ren Y M, et al. The impact of composting with different aeration rates on maturity variation and emission of gas concluding N[J]. Journal of Agro-Environment Science, 2010, 29(9): 1814-1819.(in Chinese with English abstract)
|
| [18] |
张继宁, 吕凡, 邵立明, 等. 木炭对污泥堆肥有机质减量和腐熟度的影响[J]. 同济大学学报, 2014, 42(2): 577-581.
Zhang J N, Lv F, Shao L M, et al. Impact of wood biochar on organics degradation and maturity of sewage sludge[J]. Journal of Tongji University, 2014, 42(2): 577-581.
|
| [19] |
魏自民. 生物垃圾微生物强化堆肥技术[M]. 北京: 中国环境科学出版社, 2008. 14.
Wei Z M. Microbiological enhanced composting of biological waste[M]. China Environmental Science Press, 2008. 14.
|
| [20] |
Berna M P, Alburquerque J A, Moral R. Composting of animal manures and chemical criteria for compost maturity assessment[J]. Bioresource Technology, 2009, 100: 5444-5453.
|
| [21] |
Masanori S. Charcoal as a habitat for microbes and its effect on the microbial community of the underly in ghumus[J]. Oikos, 2000, 89(2): 231-242.
|
| [22] |
宋彩红, 贾璇, 李明晓, 等. 沼渣与畜禽粪便混合堆肥发酵效果的综合评价[J]. 农业工程学报, 2013, 29(24): 227-234.
Song C H, Jia X, Li M X, et al. Comprehensive evaluation of co-composting fermentation effect of biogas residue mixed with livestock manure[J]. Transactions of the Chinese Society of Agricultural Engineering, 2013, 29(24): 227-234.
|
| [23] |
Gray K R, Sherman, K, Biddlestone A J. A review of composting part 1[J]. Process Biochemistry, 1971, 6: 32-36.
|
| [24] |
Wang C, Guo X H, Hui D D, et al. Microbial dynamics and enzyme activities during rapid composting of municipal solid waste-A compost maturity analysis perspective[J]. Bioresource Technology, 2008, 99: 6512-6519.
|
| [25] |
Sullivan D M, Bary A I, Thomas D R, et al. Food waste compost effects on fertilizer nitrogen efficiency, available nitrogen, and tall fescue yield[J]. Soil Science Society of America Journal, 2002, 66: 154-161.
|
| [26] |
Tuomela M, Vikmanb M, Hatakka A, et al.Biodegradation of ligninino compost environment A review[J]. Bioresource Technology, 2000, 72(2):169-183.
|
| [27] |
Demisie W, Liu Z, Zhang M. Effect of biochar on carbon fractions and enzyme activity of red soil[J]. Catena, 2014, 121: 214-221.
|
| [28] |
Jonathan D, Goro U, Yudai S, et al. Charcoal volatile matter content influences plant growth and soil nitrogen transformations[J]. Soil Science Society of America Journal, 2010, 74(4): 1259-1270.
|
| [29] |
Girvan M S, Campbell C D, Killham K, et al. Bacterial diversity promotes community stability and functional resilience after perturbation[J]. Environmental Microbiology, 2005, 7(3): 301-313.
|
| [30] |
Grossman J M. Amazonian anthrosols support similar microbial communities that differ distinctly from those extant in adjacent, unmodified soils of the same mineral[J]. Microbial Ecology, 2010, 60(1): 192-205.
|
| [31] |
杨恋, 杨朝晖, 曾光明, 等. 好氧堆肥高温期的嗜热真菌和嗜热放线菌群落结构[J]. 环境科学学报, 28(12): 2514-2521.
Yang L, Yang Z H, Zeng G M, et al. Succession of the rmophilic fungi and actinomycetes communities during the the rmophilic period of aerobic composting[J]. Acta Scientiae Circumstantiae, 28(12): 2514-2521.
|
| [32] |
Glaser B, Lehmann J, Zech W. Ameliorating physical and chemical properties of highly weathered soils in the tropics with charcoal-A review[J]. Biology and Fertility of soils, 2002, 35(4): 219-230.
|
| [33] |
Pietikainen J, Kiikkila O, Fritze H. Charcoal as a habitat for microbes and its effect on the microbial community of the underlying humus[J]. Oikos, 2000, 89(2): 231-242.
|
| [34] |
Zhang Y C, Li H D. Impact of biochar application to a Mediterranean wheat crop on soil microbial activity and greenhouse gas fluxes[J]. Chemosphere, 85(9): 1464-1471.
|
| [35] |
Dempster D N, Gleeson D B, Solaiman Z M, et al. Decreased soil microbial biomass and nitrogen mineralisation with Eucalyptus biochar addition to a coarse textured soil[J]. Plant and Soil, 354(1/2): 311-324.
|
| [36] |
David A L, Pierce F, Dedrick D, et al. Impact of biochar amendments on the quality of a typical Midwestern agricultural soil[J]. Geoderma, 158(3-4): 443-449.
|
| [37] |
Knicker H. How does fire affect the nature and stability of soil organic nitrogen and carbon: A review[J]. Biogeochemistry, 2007, 85(1): 91-118.
|
| [38] |
孙向平. 不同控制条件下堆肥过程中腐殖质的转化机制研究[D]. 北京: 中国农业大学博士学位论文, 2016.
Sun X P. The humuns transformation mechanism research during composting under different controlled conditions[D]. Beijing: PhD Dissertation of China Agricultural University, 2016.
|
| [39] |
Brunetti G, Soler R P, Matarrese F, et al. Composition and structural characteristics of humified fractions during the co-composting process of spent mushroom substrate and wheat straw[J]. Journal of Agricultural and Food Chemistry, 2009, 57(22): 10859-10865.
|
| [40] |
Amir S, Lemee H M, Merlina G. Structural characterization of humic acids, extracted from sewage sludge during composting, by thermochemolysis-gas chromatography-mass spectrometry[J]. Process Biochemistry, 2006, 41(2): 410-422.
|
| [41] |
NY525-2012, 有机肥[S].
NY525-2012, Manure[S].
|
| 1. |
潘德龙，宋彩红，陈志茹，高云祥，齐辉. 沼渣堆肥过程中水溶性有机物的稳定化研究. 环境污染与防治. 2024(04): 530-535 .
| |
| 2. |
王鑫源，程国伟，朱晓波，刘焕良，刘萌，肖磊，张世威，刘辉. 鸡粪好氧堆肥技术研究进展. 畜牧兽医杂志. 2024(04): 22-28 .
| |
| 3. |
康建邨，李波，方祥，陈子璇，范世锁，郑苇. 厨余垃圾厌氧沼渣快速陈腐通风和加热策略探析. 环境卫生工程. 2023(01): 37-42 .
| |
| 4. |
张方娟，宋雪英，张玉兰，魏建兵. 生物炭在土壤中的生态效应研究进展. 生态科学. 2023(03): 241-248 .
| |
| 5. |
姬快乐，高莹，贾晓桐，孙宁，王萌萌，吴瑕，赵立琴，范博文，杨凤军. 玉米浆对大球盖菇培养料发酵的影响. 西北农业学报. 2023(05): 762-771 .
| |
| 6. |
王琼，王永歧，马怡，李哲，王岩，郭笑盈. 堆肥腐殖酸演化规律及堆肥工艺对其影响的研究进展. 应用化工. 2023(10): 2865-2869 .
| |
| 7. |
马彩云，李伟，李杰，吴伟霞，唐朱睿. 有机固体废物高效腐殖化微生物调控原理与技术. 化工环保. 2022(02): 134-142 .
| |
| 8. |
郑苇，高波，马换梅，李波，陈子璇. 有机废弃物厌氧沼渣堆肥参数浅析. 四川环境. 2022(04): 324-332 .
| |
| 9. |
雷仁清，秦文婧，刘佳，陈静蕊，徐昌旭，万里平，龚贵金，陈晓芬. 不同碳氮比猪粪沼渣堆肥及其产品对水稻种子萌发的影响. 中国土壤与肥料. 2022(08): 205-211 .
| |
| 10. |
孟利，杜彩萍. 大鼠His-Akt1重组蛋白的真核表达、蛋白纯化及活性鉴定. 生物技术通报. 2021(12): 98-103 .
| |
| 11. |
李太魁，王小非，郭战玲，张香凝，寇长林，王彦江. 添加生物炭对猪粪好氧堆肥过程氮素转化与氨挥发的影响. 生态环境学报. 2021(04): 874-879 .
| |
| 12. |
李昌宁，苏明，姚拓，韩琪琪，梁建军，冉福，刘子越，刘玉祯，柴澍杰，滚双宝. 微生物菌剂对猪粪堆肥过程中堆肥理化性质和优势细菌群落的影响. 植物营养与肥料学报. 2020(09): 1600-1611 .
本站查看
| |
| 13. |
葛勉慎，周海宾，沈玉君，孟海波，周俊，董姗姗，李冉，张曦，程红胜，王健. 添加剂对牛粪堆肥不同阶段真菌群落演替的影响. 中国环境科学. 2019(12): 5173-5181 .
|
DownLoad: